aviation investigation Archives - Page 12 of 15

Auckland, New Zealand: An Airbus A320‑Neo operated by Air New Zealand (Flight NZ249) experienced an uncommanded engine shutdown mid‑flight last year, due to a defective fire‑switch, the Transport Accident Investigation Commission (TAIC) confirmed in its interim report released on 4 December 2025. The incident occurred on 1 December 2024, when the aircraft was en route from Wellington to Sydney. Approximately 40 minutes after takeoff, the No. 2 engine unexpectedly shut down following activation of the overhead fire‑switch despite no pilot input. The crew declared a mayday and safely diverted to Auckland Airport, with all 154 passengers and crew unharmed. TAIC’s report identifies internal damage to the fire‑switch mechanism as the primary cause. A retaining pin inside the switch had bent, reducing the latching security and allowing vibration or normal operation to trigger the switch inadvertently. Inspections revealed that the panel surrounding the switch also showed signs of deformation, further contributing to the uncommanded activation. “The fire‑switch is designed to be manually operated only in case of an actual engine fire,” TAIC noted. “Its activation without pilot input posed a significant safety risk.” The commission also highlighted that the same fire‑panel design is used across the global A320 fleet indicating that other aircraft could potentially be affected. The switch manufacturer had issued service bulletins in late 2024 recommending inspection of previously repaired panels, but those checks focused on visually detectable external damage. Following the ANZ incident, Airbus expanded its guidance to inspect all affected fire‑panels for any signs of deformation within 1,000 flight cycles. The European Union Aviation Safety Agency (EASA) has since issued an Airworthiness Directive mandating such inspections and, where necessary, replacement of defective panels. Air New Zealand reportedly removed suspect panels from its fleet in early December 2024. On 28 November 2025, Airbus triggered another major safety action ordering a global recall of approximately 6,000 A320‑family aircraft, following a serious mid‑air flight‑control issue linked to corruption of flight‑control data under intense solar radiation. In a statement, Airbus described the recall as “precautionary,” urging all operators worldwide to apply an immediate software rollback (or, where required, hardware modifications) before affected aircraft are flown again. This recall reportedly the largest in Airbus’s 55‑year history affects over half of the global A320 fleet and has already prompted airlines across the U.S., Europe, Asia and beyond to ground jets for urgent software updates.

Air NZ A320-Neo Suffered Uncommanded Engine Shutdown Due to Faulty Fire-Switch: TAIC

Aviation Today News Desk / December 4, 2025

Auckland, New Zealand: An Airbus A320‑Neo operated by Air New Zealand (Flight NZ249) experienced an uncommanded engine shutdown mid‑flight last

Tiruchirappalli, India: A Dubai-bound Air India Express flight was forced to make an emergency landing at Tiruchirappalli International Airport on Monday after the crew detected a technical malfunction shortly after take-off. The aircraft landed safely after remaining airborne for nearly two hours as part of standard safety procedures. No injuries were reported. The aircraft, operating as Flight IX 611, departed Trichy at around 1:55 PM, carrying approximately 152 people onboard, after a brief delay from its scheduled departure time of 12:45 PM. Soon after take-off, pilots reported a technical snag and immediately entered a holding pattern over the Tiruchirappalli and Pudukottai airspace to burn excess fuel before attempting a safe landing. After circling for nearly two hours, the aircraft touched down safely at 3:53 PM, triggering emergency protocols at the airport. Fire and rescue services remained on standby as a precautionary measure. Airport sources said 11 passengers were offloaded following the return. The remaining 135 travellers, along with six crew members, were shifted to another aircraft through a one-to-one transfer process. Air India Express has not yet disclosed the exact nature of the technical fault. Officials confirmed that a detailed investigation will be conducted in line with aviation safety protocols. Airport authorities stated that the incident was handled efficiently and that passenger safety was never compromised. Several passengers reportedly contacted relatives after noticing the aircraft was not gaining cruising altitude, sparking momentary concern before the safe landing was confirmed. The Directorate General of Civil Aviation (DGCA) is expected to review the technical report once it is submitted by the airline.

Incidents

Dubai-Bound Air India Express Flight Makes Safe Emergency Landing At Trichy After Snag

Aviation Today News Desk / December 2, 2025

Tiruchirappalli, India: A Dubai-bound Air India Express flight was forced to make an emergency landing at Tiruchirappalli International Airport on

Vilnius, Lithuania: A regional jet operated by LOT Polish Airlines slid off the taxiway at Vilnius Airport today, forcing a temporary closure of the runway. All 63 passengers and four crew members on board disembarked safely, and no injuries have been reported, airport and airline officials confirmed. The aircraft involved was an Embraer E170 (registration SP-LDK), operating flight LO771 from Warsaw (Poland) to Vilnius (Lithuania). The flight landed at 13:43 local time (runway 01) without apparent issues. However, while taxiing toward the stand, the aircraft veered off the paved surface sliding onto the northern side of the airfield. Flight-tracking records show the plane had slowed to under 30 knots before the final taxiway turn but nevertheless “continued straight,” failing to make the turn and leaving the paved taxiway surface. Emergency services including fire and ground-handling teams responded immediately. Passengers disembarked via mobile stairs and were safely transported to the terminal. No injuries or medical emergencies have been reported. The airline confirmed the return flight, LO772 from Vilnius to Warsaw, has been cancelled pending technical inspection. LOT’s technical team, together with airport authorities, is assessing the aircraft and runway condition before any further operations resume. Following the incident, Vilnius Airport under the authority of Lithuanian Airports (LTOU) issued a NOTAM and closed its runway, suspending all arrivals and departures. Initial estimates suggested resumption by 17:00 local time, but the closure was later extended until at least 22:00 as recovery and inspection work continued. The closure has affected other scheduled flights. Passengers on flights due to depart or arrive during the shutdown were advised to contact their airlines for updated schedules. The incident occurred amid heavy, wet snowfall in Vilnius part of a broader winter weather surge across Lithuania. The buildup of snow and slush likely contributed to poor friction on taxiway/runway surfaces. Meteorological warnings had been issued earlier, cautioning travelers about hazardous conditions. While the exact cause has not yet been determined, local media and aviation-safety observers have highlighted slippery surfaces from snow and wet slush as plausible contributing factors. Immediately after the incident, the airport’s Emergency Commission convened a meeting. The gathering included the transport minister, justice-department officials, and LTOU management, signaling the start of a formal investigation. Authorities have yet to publish a preliminary report. The investigation is expected to examine multiple aspects including runway/taxiway surface condition, snow/ice removal procedures, friction measurements, aircraft handling during taxi, and possible human or technical errors.

Incidents

LOT Polish Airlines Jet Slides Off Taxiway At Vilnius Airport, Runway Shut After Snow

Aviation Today News Desk / November 27, 2025

Vilnius, Lithuania: A regional jet operated by LOT Polish Airlines slid off the taxiway at Vilnius Airport today, forcing a

Kolwezi, Africa: The Democratic Republic of Congo’s Mines Minister, Louis Watum Kabamba, along with other passengers, survived a runway overrun and fire at Kolwezi Airport on Monday, officials confirmed. The chartered aircraft, an Embraer ERJ-145 operated by Airjet Angola (registration D2-AJB), was on a flight (MBC-100) from Lubumbashi to Kolwezi when it veered off runway 29 during landing and caught fire. According to the bureau of aircraft accident archives, both main landing gears were reportedly sheared off as the airplane came to a halt, and the tail section ignited. All 26 passengers and 3 crew evacuated; there are no reported fatalities or serious injuries. Initial reports suggest the aircraft touched down before a displaced threshold on runway 29, which was under maintenance. The Notam issued for Kolwezi Airport indicated that 1,000 metres of the runway were being resurfaced, reducing the effective landing distance. According to the Bureau of Aircraft Accidents Archives, this could have contributed to the gear collapse. Eyewitnesses and social media footage show thick smoke rising from the rear fuselage as passengers escaped, some via overwing exits. Isaac Nyembo, communications adviser to Minister Kabamba, said around 20 people were evacuated before the fire spread, though luggage was damaged. Concerns have also been raised over emergency response readiness at Kolwezi Airport. No fire trucks arrived for several minutes, despite the airport being categorized to require rapid rescue capability. Minister Kabamba and his delegation were heading to Kalondo, near Kolwezi, following a recent mining accident in which over 30 workers died in a bridge collapse. The delegation was expected to assess the damage, console affected families, and coordinate government support. An investigation has been launched by the DRC’s aviation authority (BPEA) into the cause of the runway excursion and fire. Kolwezi Airport, located in Lualaba Province, has a single asphalt runway (11/29), around 2,410 metres long. Aviation experts have pointed out that infrastructure challenges, such as runway maintenance, coupled with limited firefighting capacity, may pose ongoing safety risks.

Aircraft Crashes

29 Aboard Survive As ERJ-145 Overruns Kolwezi Airport Runway And Catches Fire

Aviation Today News Desk / November 18, 2025

Kolwezi, Africa: The Democratic Republic of Congo’s Mines Minister, Louis Watum Kabamba, along with other passengers, survived a runway overrun

Incidents

Federal Judge Declines More Jail For Pilot Who Tried To Cut Fuel To Alaska Jet Engines

Aviation Today News Desk / November 18, 2025

Portland, United States: A federal judge has ruled that Joseph David Emerson, a former Alaska Airlines pilot, will not serve

Kolkata, India: A SpiceJet flight operating from Mumbai to Kolkata made an emergency landing at Netaji Subhas Chandra Bose International Airport late Sunday night after reporting an engine malfunction during descent, officials confirmed. The aircraft, operating as SpiceJet flight SG 670, took off from Chhatrapati Shivaji Maharaj International Airport (Mumbai) and was nearing Kolkata when the flight crew reported a technical issue involving one of its engines. Air traffic control promptly declared a full emergency, and rescue and fire services were placed on standby. According to airport officials, the aircraft landed safely at 11:38 p.m. (IST) and taxied to the parking bay without further incident. All passengers and crew disembarked safely, and no injuries were reported. The airline did not disclose specific details about the nature of the engine failure. Technical engineers have begun an inspection of the aircraft to determine the cause of the malfunction. No smoke or fire was detected upon landing, according to airport emergency services. Authorities withdrew the full emergency status shortly after touchdown, confirming that the situation was under control. The Directorate General of Civil Aviation (DGCA) is expected to review the incident as part of its routine safety oversight, officials familiar with the matter said. Industry experts note that while modern twin-engine aircraft are designed to fly safely on one engine, in-flight engine shutdowns trigger mandatory reporting and inspection protocols under DGCA norms.

Incidents

SpiceJet Mumbai–Kolkata Flight Makes Safe Emergency Landing After Engine Failure

Aviation Today News Desk / November 11, 2025

Kolkata, India: A SpiceJet flight operating from Mumbai to Kolkata made an emergency landing at Netaji Subhas Chandra Bose International

Dagestan, Russia: A Russian Ka-226 light utility helicopter operated by Kizlyar Electromechanical Plant (KEMZ) crashed in the Republic of Dagestan on Friday, after catching fire mid-air, killing at least five people, including senior officials of the defense manufacturer. The helicopter, registered RA-19307, was flying from Kizlyar to Izberbash on November 7 when it reportedly caught fire while airborne near the village of Achi-Su, close to the Caspian Sea. videos circulating on Russian and international media show the aircraft’s tail section detaching as it spun uncontrollably before slamming into the ground and erupting into flames. According to a statement by the plant, the dead included KEMZ’s deputy general director, chief engineer, and chief designer. Two other employees who were initially reported injured also succumbed to their injuries, KEMZ, part of the Rostec defense conglomerate, manufactures the Ka-226 multipurpose helicopter used by Russian armed forces and civilian operators. Video evidence reviewed by multiple outlets shows the pilot struggling to stabilize the aircraft after its tail rotor failed mid-air. Witnesses reported seeing the helicopter hover momentarily before the fuselage ignited and fell to the ground. The aircraft crashed into an unoccupied private house, causing no ground casualties, regional authorities confirmed. Russia’s Federal Air Transport Agency (Rosaviatsia) classified the event as a “disaster” and opened an inquiry into possible violations of flight-safety regulations. The Investigative Committee of Russia has launched a separate criminal probe into potential breaches of airworthiness and maintenance procedures. Preliminary assessments suggest a mechanical or structural failure in the tail section may have triggered the inflight breakup. Experts also noted that ongoing sanctions have limited access to certain aviation components, raising maintenance and reliability concerns across several Russian aircraft fleets. The pilot appeared to have continued flight despite visible structural damage before attempting an emergency landing. Aviation analysts have called the decision “questionable,” given the apparent loss of tail-rotor control, which is critical for helicopter stability. The Kamov Ka-226 is a twin-engine, light utility helicopter designed for reconnaissance, medical evacuation, and transport missions. Known for its coaxial rotor configuration, the type has been in service since the late 1990s and is produced by KEMZ under license. The same model was previously involved in several non-fatal incidents linked to gearbox and rotor-system issues. Authorities have not yet released the flight data or cockpit voice recorders, and the investigation is expected to continue in coordination with Russia’s Interstate Aviation Committee.

Helicopter Crash

Five Dead As Russian Ka-226 Helicopter Breaks Apart And Crashes In Dagestan

Aviation Today News Desk / November 10, 2025

Dagestan, Russia: A Russian Ka-226 light utility helicopter operated by Kizlyar Electromechanical Plant (KEMZ) crashed in the Republic of Dagestan

Kuwait City, Kuwait: A Kuwait Airways flight bound for Manila was delayed early Friday morning after the aircraft encountered a minor technical malfunction while taxiing for departure at Kuwait International Airport (KWI), authorities confirmed. The incident involved Kuwait Airways Flight KU417, a scheduled service from Kuwait City to Manila. The aircraft suffered a braking system malfunction shortly before takeoff. The fault reportedly caused a brief halt in aircraft movement on the taxiway but did not lead to any injuries or fire onboard. “The situation was brought under control quickly, and no injuries were reported among passengers or crew,” Kuwait’s Public Authority for Civil Aviation (PACA) said in an official statement. “The technical teams carried out immediate safety checks, and the aircraft was secured in accordance with international aviation protocols.” Airport ground crews, fire services, and airline maintenance teams responded promptly to the alert. The aircraft, which had 284 passengers onboard, was towed back to the gate area for inspection. Passengers were deboarded safely and provided refreshments while Kuwait Airways arranged an alternate aircraft to operate the route. A replacement aircraft later departed Kuwait for Manila around 12:20 p.m. local time, several hours after the initial schedule. The airline confirmed that no flight operations or other services at the airport were affected by the incident. The Public Authority for Civil Aviation – Kuwait (PACA) has initiated a standard investigation to determine the cause of the malfunction. Preliminary findings suggest a mechanical issue in the braking system, but officials emphasized that it posed no threat to flight safety. PACA reaffirmed that all safety procedures were executed without delay, adding that the aircraft’s crew followed prescribed emergency checklists effectively. “Passenger safety is our foremost priority. Incidents of this nature are handled in accordance with international standards and in coordination with Kuwait Airways’ engineering division,” the authority said. Kuwait Airways stated that its engineering and safety teams are carrying out detailed inspections on the affected aircraft before returning it to service. The airline added that passengers who missed connecting flights were rebooked and assisted at Kuwait International Airport’s customer service desk. Operations across Kuwait Airways’ regional network reportedly continued without disruption. Aviation tracking services showed regular departures from KWI through the day. The aircraft involved remains grounded pending engineering clearance and PACA certification. No further issues or related incidents have been reported.

Incidents

Kuwait Airways Flight To Manila Delayed After A Technical Incident At Kuwait Airport

Aviation Today News Desk / November 8, 2025

Kuwait City, Kuwait: A Kuwait Airways flight bound for Manila was delayed early Friday morning after the aircraft encountered a

South Africa: South Africa’s general aviation sector is facing mounting scrutiny following a series of fatal training accidents involving student pilots. The latest tragedy claimed the lives of 26-year-old Indian trainee pilot Mayank Prajapati and 35-year-old South African pilot Martin Brown, reigniting serious concerns over safety standards, oversight, and accountability in the country’s flight-training industry. Both pilots were enrolled at Aviation Junction Flying School, based in Secunda, Mpumalanga. On 15 October 2025, they were flying separate Sling 2 training aircraft belonging to the flying school, Mayank Prajapati was flying ZU-PBD, while Martin Brown was operating ZU-PBC. He had earned his fixed-wing pilot licence around 18 months earlier through Aviation Junction Flying School. Both aircraft reportedly took off around the same time for routine training operations. Soon after departure, the two aircraft encountered poor weather, including heavy mist, drizzle, and low visibility, resulting in loss of radio and radar contact. Search and rescue teams later discovered the wreckage in separate areas of the KwaZulu-Natal Midlands, Brown’s ZU-PBC was found near Nottingham Road, while Prajapati’s ZU-PBD crashed closer to Pietermaritzburg. Brown’s body was recovered the following day, and Prajapati’s remains were transported to Pietermaritzburg Hospital for post-mortem formalities. The twin crashes have intensified calls for stronger oversight and safety reforms within South Africa’s flight-training industry. A family member of Mayank Prajapati speaking exclusively to Aviation Today, alleged that the accident resulted from air-traffic control (ATC) failures and unsafe training decisions. “The visibility that day was extremely poor, yet students were cleared to fly. Mayank was pressured to proceed despite the conditions,” the family member said. “ATC forced them to maintain altitude in thick clouds, threatening to cancel his Private Pilot Licence if he refused. That cost him his precious life.” The family member claimed that this marks the third major accident linked to Aviation Junction Flying School in recent months, pointing to what she described as “blackmailing and negligence” by training authorities. This follows a series of fatal crashes involving trainee pilots across South Africa, highlighting systemic safety gaps: October 2025 – Johannesburg A trainee pilot from Ranchi, India, Piyush Pushp died when a light training aircraft reportedly suffered engine trouble during a solo flight from the Vulcan Aviation Institute. June 2025 – KwaZulu-Natal (Greytown region) Three people were killed when a light aircraft crashed near Greytown after departing from an airstrip near Durban and heading to Pretoria. A provincial department confirmed that a female student pilot was among the fatalities November 2024 - Cullinan / Pretoria area Instructor and trainee killed in a light-aircraft crash. A light aircraft en route to Wonderboom Airport lost contact and later was found crashed east of Pretoria (Cullinan). Authorities reported the deaths of the flight instructor and the trainee; initial accounts placed the aircraft on a routine general-aviation flight before the accident. February 2024 – Westonaria, Gauteng Province A Cessna 172K registered ZS-FJU operated by Sun Quest Trading under Part 141 training operations crashed during a training flight. Two occupants were killed, flight instructor and student pilot. While investigations into many of these crashes remain ongoing, aviation-safety experts say the pattern is alarming recurring training flights, small aircraft, and adverse-weather decisions. The South African Civil Aviation Authority (SACAA) has been criticised for reactive oversight and limited enforcement capacity over smaller training schools, especially those operating older piston aircraft. Instructors have voiced concerns that many flight academies are “under-resourced but over-enrolled,” often pushing trainees to meet flying-hour targets regardless of weather or maintenance delays.

Pilot Training

Rising Toll of Student Pilot Deaths Puts South Africa’s Flight Schools Under Scrutiny

Aviation Today News Desk / November 5, 2025

South Africa: South Africa’s general aviation sector is facing mounting scrutiny following a series of fatal training accidents involving student

Boston, United States: The Federal Aviation Administration (FAA) is investigating a close-call incident at Boston Logan International Airport on Thursday afternoon, when a Delta Air Lines widebody jet and a Cape Air commuter aircraft came dangerously close to each other on intersecting runways. According to FAA officials, Delta Flight 263 an Airbus A330-900neo operating from Paris Charles de Gaulle to New York-JFK had been diverted to Boston due to weather in the New York area. The aircraft, carrying 284 passengers and 11 crew, was on approach to Logan around 4:15 p.m. ET when air traffic control ordered the pilots to perform a go-around to maintain safe separation from Cape Air Flight 548, which had been cleared for takeoff on an intersecting runway. Audio recordings from LiveATC.net, cited by multiple outlets, captured the tense exchange between the flight crews. As the Delta A330 climbed away from the runway, one of its pilots radioed, “That was close.” Moments later, a Cape Air pilot could be heard responding, “Yeah, man, not cool.” While no collision occurred and both flights landed safely, aviation experts said the proximity of the two aircraft estimated at less than half a mile at one point warranted investigation. “Even when vertical and horizontal separation remains within limits, intersecting-runway operations always carry elevated risk,” one aviation analyst told WCVB Boston. The FAA confirmed that controllers instructed the Delta crew to abort landing to “ensure safe separation” after the Cape Air flight was cleared for departure. The agency has since opened a formal investigation into the event to determine whether procedural, human, or environmental factors contributed. Both airlines confirmed that their pilots followed ATC instructions. “Delta Air Lines is cooperating fully with the FAA’s review,” the company said in a statement, adding that safety remains its top priority. Cape Air also noted that its pilots “acted in accordance with clearance and protocol.” The incident comes amid rising operational pressure on U.S. air traffic controllers, who have faced long shifts and reduced staffing levels exacerbated by the ongoing federal government shutdown. Nearly 13,000 air traffic controllers working without pay and prompting hundreds to take on second jobs to cover essential expenses. The situation, aviation unions warn, is beginning to pose serious risks to both air safety and system reliability.

Incidents

FAA Probes Close Call Between Delta A330 And Cape Air Plane At Boston Logan Airport

Aviation Today News Desk / November 3, 2025

Boston, United States: The Federal Aviation Administration (FAA) is investigating a close-call incident at Boston Logan International Airport on Thursday

aviation investigation

Air NZ A320-Neo Suffered Uncommanded Engine Shutdown Due to Faulty Fire-Switch: TAIC

Dubai-Bound Air India Express Flight Makes Safe Emergency Landing At Trichy After Snag

LOT Polish Airlines Jet Slides Off Taxiway At Vilnius Airport, Runway Shut After Snow

29 Aboard Survive As ERJ-145 Overruns Kolwezi Airport Runway And Catches Fire

Federal Judge Declines More Jail For Pilot Who Tried To Cut Fuel To Alaska Jet Engines

SpiceJet Mumbai–Kolkata Flight Makes Safe Emergency Landing After Engine Failure

Five Dead As Russian Ka-226 Helicopter Breaks Apart And Crashes In Dagestan

Kuwait Airways Flight To Manila Delayed After A Technical Incident At Kuwait Airport

FAA Probes Close Call Between Delta A330 And Cape Air Plane At Boston Logan Airport

Quick Links

Navigate

General Support

News Desk Support