maintenance check Archives

Washington, United States: The Federal Aviation Administration (FAA) has issued an Emergency Airworthiness Directive targeting all Embraer Model EMB-545 and EMB-550 aircraft, citing a potentially catastrophic failure risk involving the aircraft’s pitch trim system. The directive, which became effective immediately upon receipt, follows reports of in-service failures in one load path of the pitch trim actuator, a critical component that controls the horizontal stabilizer. According to the FAA, such failures, if unaddressed, could escalate into a dual load-path failure, potentially allowing the stabilizer to move freely under aerodynamic forces and resulting in loss of control of the aircraft. The action stems from an earlier emergency directive issued by Brazil’s aviation authority, the Agência Nacional de Aviação Civil (ANAC), under Emergency AD 2026-04-02, which identified the unsafe condition during scheduled maintenance checks. Specifically, failures were observed during operational checks of pitch trim actuator irreversibility, raising concerns over the system’s redundancy. Under bilateral aviation safety agreements, ANAC notified the FAA of the issue, prompting the U.S. regulator to determine that the same unsafe condition is likely to exist or develop in aircraft operating under U.S. jurisdiction. The FAA directive mandates operators to carry out operational checks of the pitch trim actuator, with an option to perform a pitch trim verification, in accordance with the ANAC procedures. If the system fails, defined as a “TEST FAILED” status after five minutes or repeated “TEST ABORTED” results after five attempts operators must replace the actuator before further flight. Additionally, if a replacement is required, a subsequent operational check must be performed on the new actuator to ensure airworthiness before the aircraft returns to service. The directive also requires operators to report inspection and verification data within 10 days, either after completing the checks or from the date of receiving the directive, depending on when the inspection was conducted. Citing an urgent safety risk, the FAA bypassed the standard notice-and-comment rulemaking process under the Administrative Procedure Act, invoking “good cause” to enforce the directive immediately. The agency stated that the short compliance window and the severity of the potential failure made prior public consultation impractical and contrary to the public interest. “The risk to the flying public justifies forgoing notice and comment,” the FAA noted, emphasizing that unresolved actuator failures could lead to uncontrolled stabilizer movement and loss of aircraft control. The FAA described the directive as an interim action, noting that the required reporting will help manufacturers better understand the root cause, scope, and frequency of the failures. Based on the findings, further rulemaking or permanent corrective measures may follow. The directive applies to all EMB-545 and EMB-550 aircraft, regardless of certification category, and falls under ATA Chapter 27 (Flight Controls). No previous airworthiness directives are superseded by this action. The FAA issued the directive under its statutory authority outlined in Title 49 of the United States Code, which mandates the agency to ensure safe flight operations by prescribing necessary regulations and procedures.

FAA Issues Emergency AD For Embraer EMB-545/550 After Brazil Flags Pitch Trim Risk

Aviation Today News Desk / April 22, 2026

Washington, United States: The Federal Aviation Administration (FAA) has issued an Emergency Airworthiness Directive targeting all Embraer Model EMB-545 and […]

Mumbai, India: An Air India flight bound for Bengaluru was forced to return to Mumbai shortly after takeoff in the early hours of April 9, 2026, after experiencing an engine stall mid-air, prompting the crew to issue a “PAN PAN” emergency call. The incident involved flight AI2812, operated by an Airbus A320neo aircraft. Scheduled to depart at around 2:05 AM, the flight took off at approximately 2:15 AM but encountered technical issues within minutes of departure, forcing a return to the origin airport by around 2:35 AM. According to officials familiar with the development, one of the aircraft’s engines identified as engine number 2 stalled shortly after takeoff. The pilots subsequently issued a “PAN PAN” call, an internationally recognized radio signal indicating an urgent situation that requires priority handling but is not immediately life-threatening. Passengers onboard reported hearing a loud noise during the climb and observed sparks emanating from the affected engine. Some passengers also mentioned water leakage inside the cabin during the initial phase of the flight. Airport authorities activated a local standby as a precaution while the aircraft made its return. The flight landed safely in Mumbai without any injuries reported among passengers or crew. In an official statement, Air India said the aircraft “returned to Mumbai shortly after take-off as a precaution due to a suspected technical issue, in accordance with standard operating procedures,” adding that the aircraft has been grounded for detailed technical inspection. The airline also confirmed that passengers were provided assistance upon landing and that an alternative aircraft was arranged to complete the journey, which departed later in the morning. The spokesperson said, “We regret the inconvenience caused to our passengers. Our Mumbai airport teams provided immediate assistance, and an alternative aircraft was arranged to operate the flight. The safety and wellbeing of our passengers and crew remain Air India’s top priority.” A “PAN PAN” call, derived from the French word panne (meaning breakdown), is used in aviation to signal urgency without immediate danger to life, and is considered less severe than a “MAYDAY” distress call. Investigations into the exact cause of the engine stall are currently underway.

Incidents

Air India Flight Returns To Mumbai After Mid-Air Engine Stall, PAN PAN Call Issued

Aviation Today News Desk / April 10, 2026

Mumbai, India: An Air India flight bound for Bengaluru was forced to return to Mumbai shortly after takeoff in the

Philadelphia, United States: An American Eagle regional flight operated by PSA Airlines made an emergency diversion to Philadelphia International Airport on Wednesday morning after the crew reported a technical malfunction involving the aircraft’s nose landing gear steering system, prompting a precautionary landing. The aircraft, a Bombardier CRJ200/CRJ700 regional jet, was operating a scheduled service from Washington Reagan National Airport (DCA) to Portland International Jetport, Maine (PWM) when the issue occurred shortly after departure. According to aviation tracking data and official statements, the flight diverted to Philadelphia approximately 30 minutes into the journey after the crew detected abnormal hydraulic and steering behavior affecting the landing gear system. The aircraft landed safely at Philadelphia International Airport (PHL) around 10:20 a.m. local time, where emergency services were placed on standby as a precaution. No injuries were reported among the approximately 65 passengers and four crew members onboard. Passengers were later accommodated on a replacement aircraft to continue their journey to Maine, reaching their destination later the same day after several hours of delay. American Airlines confirmed the incident, stating that the aircraft was removed from service for a full technical inspection following the safe landing. The airline also said that all standard safety procedures were followed. The Federal Aviation Administration (FAA) has initiated a review into the incident to determine the cause of the hydraulic and steering malfunction. Initial reports suggest a nose gear steering system fault, a critical component used for directional control during taxiing and landing rollout. The aircraft involved is part of the Bombardier CRJ family, widely used in regional operations across North America. These aircraft rely heavily on hydraulic systems to control landing gear steering and braking systems, making any malfunction a serious safety concern requiring immediate diversion. Preliminary reports indicate there was no fire, smoke, or loss of control during the flight. The aircraft reportedly circled briefly before lining up for a controlled landing in Philadelphia under normal emergency protocols. The aircraft remains grounded for maintenance inspection, and investigators are expected to examine hydraulic systems, nose gear assemblies, and flight control computers as part of the FAA-led inquiry.

Incidents

American Eagle Diverts To Philadelphia After Mid-Air Steering Issue; FAA Investigates

Aviation Today News Desk / April 3, 2026

Philadelphia, United States: An American Eagle regional flight operated by PSA Airlines made an emergency diversion to Philadelphia International Airport

Incidents

American Eagle Flight Returns To Raleigh-Durham Airport After Smoke Alert Mid-Air

Aviation Today News Desk / March 24, 2026

Morrisville, United States: An American Eagle regional flight was forced to return to Raleigh-Durham International Airport shortly after takeoff on

Incidents

China Southern A330 Jet Hit By A Bird Strike, Loses Nose Radome After Shanghai Takeoff

Aviation Today News Desk / March 23, 2026

Shanghai, China: A China Southern Airlines Airbus A330 was forced to make an emergency return shortly after departure from Shanghai

Manchester, United Kingdom: An EasyJet Airbus A320-200 operating flight U2-3375 from Liverpool John Lennon Airport (LPL) to Fuerteventura Airport (FUE) in Spain was forced to divert to Manchester Airport (MAN) on 18 February 2026, shortly after departure, after the flight crew reported a technical issue during the initial climb. The aircraft, registered G-EZPE, had just departed Liverpool and was climbing through approximately 4,000 feet when the pilots detected vibrations in the left-hand engine (engine No. 1). According to aviation tracking and incident reports, the crew halted the climb and entered a holding pattern while assessing the situation before electing to divert to Manchester for a precautionary landing. The crew declared an emergency in accordance with standard aviation procedures. The Airbus A320 landed safely on runway 05R at Manchester approximately 40 minutes after departure, where airport emergency services met the aircraft as a precaution. Passengers and crew disembarked without reported injuries. A replacement aircraft, also an A320, registered G-EZPD later transported the passengers to Fuerteventura with a delay of about 3 hours and 45 minutes. Following the diversion, the original aircraft remained on the ground at Manchester for around 25.5 hours before being repositioned to Liverpool, where it was still located several hours later. EasyJet has not issued a detailed statement at the time of reporting, but the airline’s operational procedures require precautionary diversions when crew detect abnormalities in aircraft systems, particularly engine performance, to ensure the safety of passengers and flight crew

Incidents

EasyJet Flight Diverted To Manchester After In-Flight Engine Issue Post Take-Off

Aviation Today News Desk / February 20, 2026

Manchester, United Kingdom: An EasyJet Airbus A320-200 operating flight U2-3375 from Liverpool John Lennon Airport (LPL) to Fuerteventura Airport (FUE)

Mumbai, India: Two commercial aircraft operating at Chhatrapati Shivaji Maharaj International Airport (CSMIA) were involved in a ground collision involving their wingtips on Tuesday evening, prompting inspections and an immediate probe by aviation authorities. All passengers and crew onboard both flights were unharmed, officials confirmed. The incident occurred at approximately 7:30 pm IST when Air India flight AI 2732, bound for Coimbatore, was taxiing for departure and the IndiGo flight 6E 791 had just landed from Hyderabad and was taxiing toward the terminal. Both aircraft involved were narrow-body Airbus A320s. According to Air India, the right wingtip of its aircraft made contact with the wingtip of the IndiGo aircraft while maneuvering on the taxiway prior to taking off. The airline said the contact resulted in damage to its aircraft’s wingtip, and the aircraft was immediately grounded for technical checks as a precautionary measure. All passengers were safely deplaned, and ground teams began arranging alternative onward travel. IndiGo released a separate statement confirming that the wingtip of its aircraft operating flight 6E 791 touched the wing of another airline’s aircraft while taxiing after landing. The airline said all passengers disembarked safely, and its aircraft is undergoing maintenance inspection in line with standard protocols. The Directorate General of Civil Aviation (DGCA) dispatched a team from its Mumbai office to the site soon after the incident. DGCA officials confirmed both aircraft returned to their respective bays and were taken out of service pending inspection. The regulator has initiated an inquiry to determine the factors leading to the collision, focusing on ground vehicle and aircraft movement controls at the busy international airport. “No injuries have been reported among passengers or crew,” according to civil aviation sources, highlighting that the low-speed nature of the taxiing incident limited the impact to aircraft structures rather than human safety. The airport, which operates parallel runways and heavy traffic movements daily, did not report any significant disruptions to other flights following the incident. Authorities said that routine operations continued while the affected aircraft were inspected.

Incidents

Air India & IndiGo Aircraft Wingtips Collide At Mumbai Airport, No Injuries Reported

Aviation Today News Desk / February 4, 2026

Mumbai, India: Two commercial aircraft operating at Chhatrapati Shivaji Maharaj International Airport (CSMIA) were involved in a ground collision involving

Lanzhou, China: A Russian-registered passenger aircraft made a precautionary emergency landing at Lanzhou Zhongchuan International Airport in northwest China on Friday afternoon after declaring a distress situation while transiting Chinese airspace, Chinese authorities and international sources reported. The Azur Air flight ZF2998, operated by a Boeing 757-200, was en route from Phuket International Airport in Thailand to Barnaul, Russia when the crew activated the transponder code 7700, the internationally recognized signal for a flight emergency. According to airport and media reports, the aircraft circled near Lanzhou and conducted precautionary fuel jettisoning before safely touching down at 4:51 p.m. local time on January 23. All people onboard 239 passengers and seven crew members, totaling 246 individuals disembarked without injury, authorities said. Following the landing, airport officials confirmed that regular departure and arrival operations were maintained without disruption. Passengers have since been transported to accommodation in Lanzhou as part of post-flight arrangements by airport and airline representatives. Initial reports from state and international outlets indicate the emergency diversion was linked to a malfunction in the aircraft’s right engine, prompting the crew’s decision to divert for safety reasons. Specialists are expected to conduct detailed technical inspections of the airframe and propulsion systems. A spokesperson for the airline told media that the aircraft’s technical condition will be evaluated thoroughly to determine the precise cause of the in-flight emergency. A transponder code of 7700 is used globally to signal an aircraft is experiencing a serious in-flight emergency requiring immediate coordination with air traffic control and priority handling. Aviation safety experts note that diversion under such conditions is a routine but critical response to ensure passenger and crew safety.

Incidents

Azur Air Flight Boeing 757 Makes Emergency Landing In Lanzhou After Mid-Air Alert

Aviation Today News Desk / January 24, 2026

Lanzhou, China: A Russian-registered passenger aircraft made a precautionary emergency landing at Lanzhou Zhongchuan International Airport in northwest China on

Katunayake, Sri Lanka: A Turkish Airlines Airbus A330 operating Flight TK-733 from Colombo to Istanbul made a safe emergency landing early Wednesday morning at Bandaranaike International Airport (BIA) after the crew detected a technical issue with the aircraft’s landing gear shortly after departure, according to airport authorities and multiple media reports. The wide-body aircraft, carrying 202 passengers and 10 crew members, departed BIA at around 10:00 p.m. local time on Tuesday. Shortly after take-off, the flight crew identified a problem with the landing gear and opted to return to the airport as a precautionary measure. In accordance with standard safety procedures, the aircraft circled over Sri Lankan airspace, including areas near Colombo and Chilaw, to burn excess fuel and reduce landing weight before the emergency return. Airport officials placed the runway on emergency standby, with fire and rescue teams, ambulances, and other emergency response units deployed in anticipation of the aircraft’s return. At approximately 00:28 a.m. local time, the Turkish Airlines flight made a safe touchdown at BIA. All passengers and crew disembarked without injury, and emergency services were subsequently stood down. Officials noted that regular flight operations at the airport continued during the incident and there were no reported disruptions to other scheduled services. Investigations are expected to be carried out to determine the precise cause of the landing gear issue. Passengers aboard the flight were assisted following disembarkation, with arrangements made for onward travel and accommodation as necessary.

Incidents

Turkish Airlines Flight Makes Safe Landing At BIA After Technical Fault Mid-Air Alerts

Aviation Today News Desk / December 17, 2025

Katunayake, Sri Lanka: A Turkish Airlines Airbus A330 operating Flight TK-733 from Colombo to Istanbul made a safe emergency landing

Kolkata, India: A SpiceJet flight operating from Mumbai to Kolkata made an emergency landing at Netaji Subhas Chandra Bose International Airport late Sunday night after reporting an engine malfunction during descent, officials confirmed. The aircraft, operating as SpiceJet flight SG 670, took off from Chhatrapati Shivaji Maharaj International Airport (Mumbai) and was nearing Kolkata when the flight crew reported a technical issue involving one of its engines. Air traffic control promptly declared a full emergency, and rescue and fire services were placed on standby. According to airport officials, the aircraft landed safely at 11:38 p.m. (IST) and taxied to the parking bay without further incident. All passengers and crew disembarked safely, and no injuries were reported. The airline did not disclose specific details about the nature of the engine failure. Technical engineers have begun an inspection of the aircraft to determine the cause of the malfunction. No smoke or fire was detected upon landing, according to airport emergency services. Authorities withdrew the full emergency status shortly after touchdown, confirming that the situation was under control. The Directorate General of Civil Aviation (DGCA) is expected to review the incident as part of its routine safety oversight, officials familiar with the matter said. Industry experts note that while modern twin-engine aircraft are designed to fly safely on one engine, in-flight engine shutdowns trigger mandatory reporting and inspection protocols under DGCA norms.

Incidents

SpiceJet Mumbai–Kolkata Flight Makes Safe Emergency Landing After Engine Failure

Aviation Today News Desk / November 11, 2025

Kolkata, India: A SpiceJet flight operating from Mumbai to Kolkata made an emergency landing at Netaji Subhas Chandra Bose International

maintenance check

FAA Issues Emergency AD For Embraer EMB-545/550 After Brazil Flags Pitch Trim Risk

Air India Flight Returns To Mumbai After Mid-Air Engine Stall, PAN PAN Call Issued

American Eagle Diverts To Philadelphia After Mid-Air Steering Issue; FAA Investigates

American Eagle Flight Returns To Raleigh-Durham Airport After Smoke Alert Mid-Air

China Southern A330 Jet Hit By A Bird Strike, Loses Nose Radome After Shanghai Takeoff

EasyJet Flight Diverted To Manchester After In-Flight Engine Issue Post Take-Off

Air India & IndiGo Aircraft Wingtips Collide At Mumbai Airport, No Injuries Reported

Azur Air Flight Boeing 757 Makes Emergency Landing In Lanzhou After Mid-Air Alert

Turkish Airlines Flight Makes Safe Landing At BIA After Technical Fault Mid-Air Alerts

SpiceJet Mumbai–Kolkata Flight Makes Safe Emergency Landing After Engine Failure

Quick Links

Navigate

General Support

News Desk Support