FAA

Washington, United States: The Federal Aviation Administration (FAA) has issued an Emergency Airworthiness Directive targeting all Embraer Model EMB-545 and EMB-550 aircraft, citing a potentially catastrophic failure risk involving the aircraft’s pitch trim system. The directive, which became effective immediately upon receipt, follows reports of in-service failures in one load path of the pitch trim actuator, a critical component that controls the horizontal stabilizer. According to the FAA, such failures, if unaddressed, could escalate into a dual load-path failure, potentially allowing the stabilizer to move freely under aerodynamic forces and resulting in loss of control of the aircraft. The action stems from an earlier emergency directive issued by Brazil’s aviation authority, the Agência Nacional de Aviação Civil (ANAC), under Emergency AD 2026-04-02, which identified the unsafe condition during scheduled maintenance checks. Specifically, failures were observed during operational checks of pitch trim actuator irreversibility, raising concerns over the system’s redundancy. Under bilateral aviation safety agreements, ANAC notified the FAA of the issue, prompting the U.S. regulator to determine that the same unsafe condition is likely to exist or develop in aircraft operating under U.S. jurisdiction. The FAA directive mandates operators to carry out operational checks of the pitch trim actuator, with an option to perform a pitch trim verification, in accordance with the ANAC procedures. If the system fails, defined as a “TEST FAILED” status after five minutes or repeated “TEST ABORTED” results after five attempts operators must replace the actuator before further flight. Additionally, if a replacement is required, a subsequent operational check must be performed on the new actuator to ensure airworthiness before the aircraft returns to service. The directive also requires operators to report inspection and verification data within 10 days, either after completing the checks or from the date of receiving the directive, depending on when the inspection was conducted. Citing an urgent safety risk, the FAA bypassed the standard notice-and-comment rulemaking process under the Administrative Procedure Act, invoking “good cause” to enforce the directive immediately. The agency stated that the short compliance window and the severity of the potential failure made prior public consultation impractical and contrary to the public interest. “The risk to the flying public justifies forgoing notice and comment,” the FAA noted, emphasizing that unresolved actuator failures could lead to uncontrolled stabilizer movement and loss of aircraft control. The FAA described the directive as an interim action, noting that the required reporting will help manufacturers better understand the root cause, scope, and frequency of the failures. Based on the findings, further rulemaking or permanent corrective measures may follow. The directive applies to all EMB-545 and EMB-550 aircraft, regardless of certification category, and falls under ATA Chapter 27 (Flight Controls). No previous airworthiness directives are superseded by this action. The FAA issued the directive under its statutory authority outlined in Title 49 of the United States Code, which mandates the agency to ensure safe flight operations by prescribing necessary regulations and procedures.

FAA Issues Emergency AD For Embraer EMB-545/550 After Brazil Flags Pitch Trim Risk

Aviation Today News Desk April 22, 2026

Washington, United States: The Federal Aviation Administration (FAA) has issued an Emergency Airworthiness Directive targeting all Embraer Model EMB-545 and EMB-550

Washington, United States: As the U.S. government entered a partial shutdown at midnight on October 1, the Federal Aviation Administration (FAA) announced plans to furlough over 11,000 employees, approximately one-quarter of its workforce due to a lapse in federal funding. This move follows the Department of Transportation's notification that such furloughs would be necessary if the shutdown persisted. Despite the furloughs, more than 13,000 air traffic controllers are required to continue working without pay to maintain air traffic operations. The FAA is also proceeding with hiring and training new controllers, a departure from practices during previous shutdowns. The agency remains approximately 3,800 controllers short of its staffing targets. The National Transportation Safety Board (NTSB) has stated that about 25% of its 400 employees would be furloughed. However, the NTSB will continue to launch new investigations into air accidents and other incidents during the shutdown. Meanwhile, about 50,000 Transportation Security Administration (TSA) staff working airport security checkpoints would also continue working without pay. During the 35-day shutdown in 2019, absences among controllers and TSA officers increased as paychecks were missed, leading to longer checkpoint wait times and slowed air traffic in cities such as New York, which put pressure on lawmakers to resolve the funding impasse. Airline trade group, Airlines for America, representing carriers including United, Delta, American, and Southwest, warned that a lapse in funding could force the system to slow down, reducing efficiency and affecting travelers. The U.S. Travel Association, which represents airlines, hotels, car rental companies, and other travel businesses, estimated that even a partial shutdown could cost the U.S. travel sector approximately $1 billion per week. The FAA employs around 45,000 people, and the Transportation Department as a whole would furlough 12,200 of its 53,717 employees, including those at the FAA. The agency confirmed that essential certification activities covering commercial airplanes and engines, as well as commercial space launches would continue to ensure operational safety.

FAA Furloughs 11,000 as U.S. Shutdown Begins; Controllers Continue Working Unpaid

Aviation Today News Desk October 6, 2025

Washington, United States: As the U.S. government entered a partial shutdown at midnight on October 1, the Federal Aviation Administration (FAA)

Flight disruptions are mounting at Newark Liberty International Airport as a critical shortage of air traffic controllers combines with ongoing runway construction. United Airlines has already cut dozens of flights, and passengers are experiencing longer delays and unpredictable schedules. As the summer travel surge nears, the FAA faces growing scrutiny for not resolving staffing gaps in one of the nation’s busiest air corridors.

Newark Airport Faces Widespread Disruptions Amid Staffing Crisis and Runway Repairs

Aviation Today News Desk May 5, 2025

Picture Credits: Newark Liberty International Airport New Jersey, UNITED STATES: Newark Liberty International Airport (EWR), one of the busiest air travel

Wego Partners with Malaysia Airlines to Offer Expanded Flight Options

Aviation Today News Desk September 23, 2024

SkyDrive is conducting a feasibility study to integrate air taxi flights using its three-seat SD-05 eVTOL aircraft

FAA

FAA Issues Emergency AD For Embraer EMB-545/550 After Brazil Flags Pitch Trim Risk

FAA Furloughs 11,000 as U.S. Shutdown Begins; Controllers Continue Working Unpaid

Newark Airport Faces Widespread Disruptions Amid Staffing Crisis and Runway Repairs

Wego Partners with Malaysia Airlines to Offer Expanded Flight Options

Quick Links

Navigate

General Support

News Desk Support